Magnum-venus-plastech CFH-2000 Manual do Utilizador

Rev. 01/2013 CLEAN FLOW HEATER (CFH) CFH-2000 SERIES MANUAL

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 10 D. Never add MEKP to anything that is hot, since explosive decomposition may result

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 11 A. The reaction is unpredictable. Prior use of an HHC solvent without incident (cor

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 12 2.4 Catalyst Diluents Magnum Venus Plastech spray-up and gel-coat systems currently

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 13 2.8 Treatment of Chemical Injuries Great care should be used in handling the chemic

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 14 3.0 Equipment Safety WARNING Magnum Venus Plastech suggest that personal safety equ

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 15 3.2 Grounding Grounding an object means providing an adequate path for the flow of

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 16 Introduction: The MVP Clean Flow Heater (CFH) is designed to allow higher flow rat

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 17 This page was left blank intentionally.

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 18 Operations: To operate the CFH heater, just set the temperature control to mid-po

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 19 This page was left blank intentionally.

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 2 CORPORATE HEADQUARTERS and MANUFACTURING 11692 56th Court * Clearwater

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 20 Maintenance: (Refer to Parts Drawings section in the back of this manual) 1.

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 21 This page was left blank intentionally.

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 22 Troubleshooting: Two basic problems may occur with the MVP Resin Heater: • Loss

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 23 CFH-2000-AI Air Interlock units: 7. Air Switch: Disconnect wires and check microsw

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 24 Installation & Connections: NOTE: Because of the variety of electrical codes i

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 25 Parts Drawings: CFH-2110-B 110 VOLT, BASIC CLEAN FLOW HEATER CFH-2110-AI 110

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 26

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 27

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 28

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 29

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 3 TABLE OF CONTENTS: SECTION: Page TERMS & CONDITIONS OF

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 30

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 31

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 32

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 33

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 34

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 35 Revision Information: Revision: Description: Rev. 11/2010 Updated document f

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 36 MAGNUM VENUS PLASTECH CORPORATE HEADQUARTERS and MANUFACTURING 11692 56th

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 37 Certificate of Conformance: The Certificates of Conformance on the following page

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 38 This page was left blank intentionally.

CERTIFICATE OF CONFORMANCE Customer Copy Technology Center/Manufacturing 1862 Ives Ave Kent, Washington, 98032 USA Tel: (253) 854-2660 Fax (253)-8

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 4 Terms & Conditions of Sale: 1. ACCEPTANCE: Acceptance of any purchase order fro

CERTIFICATE OF CONFORMANCE MVP copy Technology Center/Manufacturing 1862 Ives Ave Kent, Washington, 98032 USA Tel: (253) 854-2660 Fax (253)-854-16

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 5 13. EXCUSABLE DELAYS: Seller shall have no liability if its performance is delayed o

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 6 22. JURISDICTION AND VENUE: The parties hereby irrevocably submit to the jurisdicti

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 7 SAFETY & WARNING INFORMATION: OPERATING YOUR POLYESTER SYSTEM SAFELY 1. Introduc

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 8 Extinguishing Media – Foam, Carbon Dioxide, Dry Chemical, Water Fog. Copies of the a

CFH -2000 Series Heater Manual Rev. 01/2013 Page | 9 2.2 Catalyst (Methyl Ethyl Ketone Peroxide) MEKP is among the more hazardous materia